Page 1 : 170 W + 170 SURR : 150 W + 150 W SURR BACK : 150 W + 150 – Continued on next page – FM STEREO FM/AM RECEIVER Sony Corporation 9-961-110-02 2004I05-1 Audio Group © 2004.09 Published by Sony Engineering Corporation...
Page 2 STR-DA5000ES AM tuner section General Inputs (Analog) Tuning range Power requirements PHONO S/N: 86 dB Models of area code U, CA: Area code Power requirements 530 – 1,710 kHz US and Canadian 120 V AC, 60 Hz (With 10-kHz tuning scale)
Page 3 SONY PARTS WHOSE PART NUMBERS APPEAR AS DE FONCTIONNEMENT. NE REMPLACER CES COM- SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- POSANTS QUE PAR DES PIÈCES SONY DONT LES LISHED BY SONY. NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
Page 4: Table Of Contents
STR-DA5000ES TABLE OF CONTENTS SERVICING NOTES 6-39. Printed Wiring Board ..........5 – PRE-OUT Board (Component Side) – (US, CND models) ............58 GENERAL 6-40. Printed Wiring Board Location of Controls ............10 – PRE-OUT Board (Conductor Side) – (US, CND models) ............59 DISASSEMBLY 6-41.
Page 5: Servicing Notes
STR-DA5000ES Ver 1.1 SECTION 1 SERVICING NOTES • MODEL IDENTIFICATION – Back Panel – PART No. Model PART No. US model 4-246-511-0 Canadian model 4-246-511-1 AEP model 4-246-511-2 Chinese model 4-246-511-4 Taiwan model 4-246-511-6 ERROR MESSAGES If there is a malfunction, the display shows a code of two numbers and a message. You can check the condition of the system by message.
Page 6 STR-DA5000ES Note: Follow the disassembly procedure in the numerical order given. D-AMP BOARD, REG BOARD SERVICE POSITION – BOTTOM VIEW – 1 six screws (BVTP3 × 8) 1 four screws (BVTP3 × 8) 1 four screws (BVTP3 × 8) 2 bottom plate 1 three screws (BVTP3 ×...
Page 7 STR-DA5000ES CIS BOARD (US, Canadian models), S-VIDEO BOARD SERVICE POSITION S-video board CIS board (US, Canadian models) insulator VIDEO BOARD SERVICE POSITION video board insulator...
Page 8 STR-DA5000ES AUDIO BOARD SERVICE POSITION audio board insulator SWITCHING REGULATOR SERVICE POSITION switching regulator...
Page 9 STR-DA5000ES DIGITAL BOARD SERVICE POSITION In checking the digital board, prepare jig (extension cable J-2501-252-A: 1.25 mm Pitch, 35 cores, Length 300 mm). D-AMP board Connect jig (extension cable J-2501-252-A) (CN1901) to the D-AMP board (CN1901) and digital board (CN2004).
Page 10: General
STR-DA5000ES SECTION 2 This section is extracted from instruction manual. GENERAL LOCATION OF CONTROLS – Front Panel – Main unit ALPHABETICAL ORDER A.F.D. 6 BASS es DECODE PRIORITY wd Digital Cinema Sound indicator DIRECT wf DIRECT indicator 2 DISPLAY ws...
Page 11: Disassembly
STR-DA5000ES SECTION 3 DISASSEMBLY • This set can be disassembled in the order shown below. 3-1. DISASSEMBLY FLOW 3-2. CASE (Page 11) 3-3. FRONT PANEL SECTION 3-4. D-AMP BOARD (Page 12) (Page 13) Note: Follow the disassembly procedure in the numerical order given.
Page 12: Front Panel Section
STR-DA5000ES 3-3. FRONT PANEL SECTION 3 screw (BVTP3 × 8) 1 wire (flat type) (17 core) (CN2007) 4 bracket (panel) 3 screw (BVTP3 × 8) 4 bracket (panel) 2 wire (flat type) (23 core) (CN2008) 5 screw (BV/RING) 5 seven screws...
Page 13: D-Amp Board
STR-DA5000ES 3-4. D-AMP BOARD 4 two screws (PSW3 × 8) 5 two ground wires 3 three connectors (CN3, CN903, CN1480) 6 Turn over the set. 1 wire (flat type) (25 core) (CN1902) 2 wire (flat type) (35 core) (CN1901) 7 three screws (BVTP3 ×...
Page 14: Test Mode
STR-DA5000ES Ver 1.1 SECTION 4 TEST MODE TUNER FACTORY PRESET MODE FLUORESCENT INDICATOR TUBE PATTERN All preset contents are reset to the default setting. CHECK MODE Procedure: All fluorescent segments are tested. When this test is activated, all [SURR BACK DECODING] [PRE- 1.
Page 15: Electrical Adjustments
STR-DA5000ES SECTION 5 ELECTRICAL ADJUSTMENTS DC OFFSET ADJUSTMENT Condition: function: MULTI CH 2 input signal: no signal (no load) volume: 0 dB Connection digital voltmeter TM1710 (TM1730, 1740, 1750, 1760, 1770) 3 pin, CN919 pin 1 (AEP, Taiwan, Chinese models) or C941 3 pin (except AEP, Taiwan, Chinese models) –...
Page 16 STR-DA5000ES Adjustment and Connection Location: – ANALOG SUB BOARD (Component Side) – RV161 RV261 RV211 RV141 RV111 RV241 RV181 RV281 – D-AMP BOARD (Conductor Side) – Front Front Surround Surround Surround back Surround back Center Speaker Speaker Speaker Speaker Speaker...
Page 17 STR-DA5000ES OSD ADJUSTMENT Connection frequency counter VIDEO board TP3501 pin 1 or pin 2 – 1. Short the TP3501 pin 4 on the VIDEO board to the GND. 2. Connect a frequency counter to the TP3501 pin 2 on the VIDEO board.
Page 18 STR-DA5000ES UP CONVERT SIGNAL LEVEL ADJUSTMENT 2. Color Level Adjustment Setting: Enter the test mode COMPONENT VIDEO oscilloscope 1. In the standby status, press the button while pressing the /B-Y jack (AC range) [INPUT MODE] [DISPLAY] buttons. VIDEO 1 2. It enters the test mode, and display as below figure.
Page 19: Diagrams
STR-DA5000ES SECTION 6 DIAGRAMS 6-1. BLOCK DIAGRAM – AUDIO IN Section – J605 (1/2) EQ AMP INPUT SELECT IC301 PHONO IC401 J605 (2/2) R-CH BUFFER 2 PHONE MD/DAT OUT IC612 BUFFER MD/DAT 3 CD/SAT IC611 CD/SACD 40 CD/SAT R-CH R-CH...
Page 20: Block Diagram - Electrical Volume Section
STR-DA5000ES 6-2. BLOCK DIAGRAM – ELECTRICAL VOLUME Section – IC111 A/D CONVERTER IC2012 17 VINL+ INPUT SELECT DSDL DSD-L IC341 RV111 16 VINL– R-CH 2CH-R ELECTRICAL VOLUME (Page 19) 2CH-L 40 COML IN IC326 SCKI DC OFFSET IC211 J601 BUFFER...
Page 21: Block Diagram - Digital 1 Section
STR-DA5000ES 6-3. BLOCK DIAGRAM – DIGITAL 1 Section – MD/DAT OPTICAL OPTICAL TRANSCEIVER IC2001 DIGITAL AUDIO BUFFER INPUT SELECT IC2007 I/F RECEIVER IC2005 (1/2) IC2121 OPTICAL • SIGNAL PATH SWITCH OPTICAL RECEIVER 1 D3 IC2007 3 DIN0 DOUT D. SD...
Page 22: Block Diagram - Digital 2 Section
STR-DA5000ES 6-4. BLOCK DIAGRAM – DIGITAL 2 Section – +2.6V D+5V D+5V REGULATOR REGULATOR IC2206 IC2255 IC2201 IC2251 D-OUT SWITCH D. SD 30 SDI2 SDO1 27 SDI1 DS01 IC2204 SDO2 28 SDI2 DS02 (Page 23) (Page 21) SDO3 35 SDI3...
Page 23: Block Diagram - Digital 3 Section
STR-DA5000ES 6-5. BLOCK DIAGRAM – DIGITAL 3 Section – LIP SYNC ADJUST IC2301 IC2401 DSD-L 35 DATA_1 DIOUT_1 83 DLI DSDL DSD-R 36 DATA_2 DIOUT_2 84 DRI DSDR DSD-C 41 DATA_5 DIOUT_3 85 DCI DSDC (Page 24) DSD-SW 42 DATA_6...
Page 24: Block Diagram - Pre Out Section
STR-DA5000ES 6-6. BLOCK DIAGRAM – PRE OUT Section – (US, Canadian) TONE/ELECTRICAL VOLUME IC2962 D/A CONVERTER T-IN IC2801 J2957 M-OUT M-IN DSDL 40 DSD3 (L) VOUT3 (L) T-OUT LOW-PASS LINE AMP PRE OUT FILTER IC2963 DSDR 41 DSD4 (R) M-OUT...
Page 25: Block Diagram - Power Amp Section
STR-DA5000ES 6-7. BLOCK DIAGRAM – POWER AMP Section – CLOCK OSC HP SW IC1471 HEADPHONE AMP HEADPHONE AMP J1001 IC1481 IC1482 R-CH PHONES X1471 HP-RY RELAY DRIVER 49.125MHz RY1480 Q1480 I. PROTECT DIGITAL POWER AMP Q1721 IC1531 SP-A RELAY DRIVER...
Page 26: Block Diagram - Video In Section
STR-DA5000ES 6-8. BLOCK DIAGRAM – VIDEO IN Section – SYNC DETECT IC3311 Q3311 D3311 1 IN HSYNC INPUT SELECT (US, Canadian) IC3421 J3401 (1/2) J3403 (2/2) J3302 J3301 D3312 VIDEO VIDEO TV/SAT 3 TV M. OUT 2ND ZONE 5 LD...
Page 27: Block Diagram - Cis/Display Section
STR-DA5000ES 6-9. BLOCK DIAGRAM – CIS/DISPLAY Section – CHROMA DECODER IC3701 J3202 (Page 22) CTLA1 CTRL A1 18 YOUT VSYNC BUFFER Q3701 HSYNC CONTROL-S I/F VIDEO AMP (US, Canadian) 7 U2OUT U2IN 19 UOUT IC861 IC3321 CVBS/YIN 6 V2OUT V2IN...
Page 28: Block Diagram - Power Supply Section
STR-DA5000ES 6-10. BLOCK DIAGRAM – POWER SUPPLY Section – T001 POWER D001 TRANSFORMER SWITCHING REGULATOR RECT IC001 D101 RECT SWITCH Q904 SWITCHING V+5V Q908 5 OUT Q001, 002 DISCHARGE 6 VCC D102 Q909 THP901 D009 VOL-DC AMP RECT IC903 TH001...
Page 29: Note For Printed Wiring Boards And Schematic Diagrams
STR-DA5000ES 6-11. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS • Circuit Boards Location Note on Printed Wiring Board: Note on Schematic Diagram: • X : parts extracted from the component side. • All capacitors are in µF unless otherwise noted. pF: µµF FL board •...
Page 30: Printed Wiring Board - Audio Board (Component Side)
STR-DA5000ES 6-12. PRINTED WIRING BOARD – AUDIO Board (Component Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. AUDIO BOARD (COMPONENT SIDE) IC321 IC322 (US, CND) IC651 IC641 IC131 IC231 IC642 IC652 IC311 C698 IC312 IC313...
Page 31: Printed Wiring Board - Audio Board (Conductor Side)
STR-DA5000ES 6-13. PRINTED WIRING BOARD – AUDIO Board (Conductor Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. (Page 51) (Page 49) (Page 75) (Page 36) (Page 36) (Page 36) (EXCEPT US, CND) (Page 75) D-AMP...
Page 32: Schematic Diagram - Audio Board (1/4)
STR-DA5000ES 6-14. SCHEMATIC DIAGRAM – AUDIO Board (1/4) – (1/4) J605 (EXCEPT US,CND) C431 R431 100p PHONO R431,531 (US,CND) C531 R531 100p 2.2k (EXCEPT US,CND) IC611(1/2) NJM4580E-D C491 100p AA10 C411 R411 R422 100p CD/DVD C591 C511 R511 R522 100p...
Page 33: Schematic Diagram - Audio Board (2/4)
STR-DA5000ES 6-15. SCHEMATIC DIAGRAM – AUDIO Board (2/4) – • See page 78 for IC Block Diagrams. EP602 (CHASSIS) (US,CND) CNP611 RELAY GND RELAY GND (Page 60) CNP610 AU GND AU GND (2/4) (Page 76) CNP608 EQ AMP DSP GND...
Page 34: Schematic Diagram - Audio Board (3/4)
STR-DA5000ES 6-16. SCHEMATIC DIAGRAM – AUDIO Board (3/4) – • See page 78 for IC Block Diagrams. (Page 32) (3/4) C615 (CHASSIS) C444 R444 C445 R443 R642 R442 C443 R441 220p 100k 22 50V R446 C442 4.7k C441 C446 R647...
Page 35: Schematic Diagram - Audio Board (4/4)
STR-DA5000ES 6-17. SCHEMATIC DIAGRAM – AUDIO Board (4/4) – • See page 78 for IC Block Diagrams. R123 R121 (4/4) C122 R124 R122 C121 C127 R136 R126 R135 R125 C328 R329 0.0022 C601 C126 IC131 J601 (CHASSIS) NJM4580E-D IC322 (EXCEPT US,CND)
Page 36: Printed Wiring Board - Analog Sub Board
STR-DA5000ES 6-18. PRINTED WIRING BOARD – ANALOG SUB Board – • :Uses unleaded solder. See page 29 for Circuit Boards Location. ANALOG SUB BOARD (COMPONENT SIDE) C268 C168 C217 C147 C248 C188 C288 C117 C116 C148 C167 C267 C216 C247...
Page 37: Schematic Diagram - Analog Sub Board
STR-DA5000ES 6-19. SCHEMATIC DIAGRAM – ANALOG SUB Board – CNP620 R119 R191 R195 R113 R216 R142 R141 R150 R149 R120 R112 R111 R196 R116 RV141 C143 C147 RV111 R192 R143 C116 C113 TU-R (Page 35) TU-L IC141 NJM4580E-D IC111 NJM4580E-D...
Page 38 STR-DA5000ES • Waveforms – DIGITAL Board – – D-AMP Board – – VIDEO Board – 1 IC2201 qs (MCLK2) 6 IC2701 qh (XOUT) qa IC1471 4 (Y) wa IC3701 qk (YOUT) (NTSC color bar mode) wh IC3701 es (CIN) (NTSC color bar mode) ea IC3601 7 (ACO) (NTSC color bar mode) 1.2 Vp-p...
Page 39: Schematic Diagram - Digital Board (1/9)
STR-DA5000ES 6-20. SCHEMATIC DIAGRAM – DIGITAL Board (1/9) – • See page 78 for IC Block Diagrams. (Page 46) (Page 45) TU2051 V3.OPT TUNER UNIT (1/9) FB2007 (Page 73) SUPPLIED AS DGND THE ASSEMBLED CN2051 D+3.3V BLOCK FB2008 (AEP) CN2001...
Page 40: Schematic Diagram - Digital Board (2/9)
STR-DA5000ES 6-21. SCHEMATIC DIAGRAM – DIGITAL Board (2/9) – • See page 38 for Waveform. (Page 46) (2/9) C2221 C2204 C2205 C2215 C2216 C2220 C2219 C2225 C2224 R2203 C2223 C2206 S-RAM R2202 IC2202 IS61LV6416-15TG XRST C2222 EXTIN XTRST X2201 C2207 13.5MHz...
Page 41: Schematic Diagram - Digital Board (3/9)
STR-DA5000ES 6-22. SCHEMATIC DIAGRAM – DIGITAL Board (3/9) – • • See page 38 for Waveforms. See page 78 for IC Block Diagrams. (Page 40) (3/9) D2122 R2144 1SS355 100k C2124 C2133 R2137 C2123 100p R2145 R2131 C2132 R2130 0.001...
Page 42: Schematic Diagram - Digital Board (4/9)
STR-DA5000ES 6-23. SCHEMATIC DIAGRAM – DIGITAL Board (4/9) – • See page 38 for Waveform. (4/9) C2272 C2252 C2269 C2253 C2268 R2270 C2259 C2267 C2251 C2254 C2257 C2256 C2255 R2252 DSP2 HCS DSP2 HDOUT R2251 DSP2 HACN S-RAM IC2253 IC61LV6416-15TG...
Page 43: Schematic Diagram - Digital Board (5/9)
STR-DA5000ES 6-24. SCHEMATIC DIAGRAM – DIGITAL Board (5/9) – • See page 78 for IC Block Diagrams. (Page 45) (Page 46) (5/9) (Page 39) R2304 R2301 R2302 R2303 R2321 IC2305 FB2301 TC7W74F C2301 C2302 C2303 C2311 C2310 R2305 1/2 DIVIDER...
Page 44: Schematic Diagram - Digital Board (6/9)
STR-DA5000ES 6-25. SCHEMATIC DIAGRAM – DIGITAL Board (6/9) – • See page 78 for IC Block Diagrams. (6/9) R2427 R2426 R2428 C2401 LRCKO BCKO R2402 BUFFER IC2428 SHIFT REGISTER TC74VHC04FT IC2404 DELAY (Page 45) TC7SH86FU IC2430 TC7WH74FU IC2427 TC7SH86FU BUFFER...
Page 45: Schematic Diagram - Digital Board (7/9)
STR-DA5000ES 6-26. SCHEMATIC DIAGRAM – DIGITAL Board (7/9) – • See page 78 for IC Block Diagrams. (7/9) CN2801 R2808 H.P-SW R2807 VOL-LAT R2806 D.MIX-LAT R2805 3RD-RY R2804 2ND-RY R2803 FUNC-LAT R2802 AUCOM-CLK(COM2) COM1-CLK R2801 AUCOM-DATA(COM2) COM1-DATA ANALOG-GND (Page 33)
Page 46: Schematic Diagram - Digital Board (8/9)
STR-DA5000ES 6-27. SCHEMATIC DIAGRAM – DIGITAL Board (8/9) – • See page 38 for Waveform. (8/9) * R2614 CN2675 (US,CND,AEP) R2608 R2732 R2621 R2622 R2618 R2617 R2616 R2624 R2625 R2666 2.2k (TW,CH) R2675 TX232 R2623 R2626 R2677 RX232 FB2675 STB+3.3V...
Page 47: Schematic Diagram - Digital Board (9/9)
STR-DA5000ES 6-28. SCHEMATIC DIAGRAM – DIGITAL Board (9/9) – • • See page 38 for Waveform. See page 78 for IC Block Diagram. (Page 46) (9/9) C2712 C2711 C2706 C2705 Q2703 RT1N141C BUFFER BUFFER BUFFER IC2708 IC2702 TC74HCT7007AF TC74HC4050AFT C2702...
Page 48: Printed Wiring Board - Digital Board (Component Side)
STR-DA5000ES 6-29. PRINTED WIRING BOARD – DIGITAL Board (Component Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. • Semiconductor Location Ref. No. Location DIGITAL BOARD (COMPONENT SIDE) D2010 C-10 D2601 JW2007 JW2010 D2701 D2702 JW2008...
Page 49: Printed Wiring Board - Digital Board (Conductor Side)
STR-DA5000ES 6-30. PRINTED WIRING BOARD – DIGITAL Board (Conductor Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. (Page 36) (Page 36) (Page 31) (Page 31) (Page 31) (Page 75) ANALOG SUB ANALOG SUB AUDIO BOARD...
Page 50: Printed Wiring Board - D-Amp Section (Component Side)
STR-DA5000ES 6-31. PRINTED WIRING BOARD – D-AMP Section (Component Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. • Semiconductor Location D-AMP BOARD (COMPONENT SIDE) Ref. No. Location C1884 R1983 R1980 D1891 D1521 D-11 R1972 R1971...
Page 51: Printed Wiring Boards - D-Amp Section (Conductor Side)
STR-DA5000ES 6-32. PRINTED WIRING BOARDS – D-AMP Section (Conductor Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. D-AMP BOARD (CONDUCTOR SIDE) • Semiconductor Location (TEST CONNECTOR) HP BOARD R1890 BOARD Ref. No. Location Ref. No.
Page 52: Schematic Diagram - D-Amp Section (1/6)
STR-DA5000ES 6-33. SCHEMATIC DIAGRAM – D-AMP Section (1/6) – • See page 78 for IC Block Diagrams. (1/6) R1890 CN1852 V+12V C1852 (Page 76) D1581 1SS367 V-9V C1880 470 16V RY +12V RY GND IC1852 IC1851 7805L 7809L (Page 73)
Page 53: Schematic Diagram - D-Amp Section (2/6)
STR-DA5000ES 6-34. SCHEMATIC DIAGRAM – D-AMP Section (2/6) – • • See page 38 for Waveforms. See page 78 for IC Block Diagrams. (Page 52) (2/6) L1473 10µH FB1470 L1472 10µH D1470 1SS367 FB1420 FB1421 R1461 FB1431 AZ17 C1426 R1471...
Page 54: Schematic Diagram - D-Amp Section (3/6)
STR-DA5000ES 6-35. SCHEMATIC DIAGRAM – D-AMP Section (3/6) – • See page 78 for IC Block Diagrams. (Page 52) (3/6) D1522 R1512 FB1522 1SS367 IC1532 C1592 HIP2101IB R1702 100k Q1722 C1612 2SA1163 0.015 R1712 PROTECT R1652 C1732 Q1652 0.01 DED TIME...
Page 55: Schematic Diagram - D-Amp Section (4/6)
STR-DA5000ES 6-36. SCHEMATIC DIAGRAM – D-AMP Section (4/6) – • See page 78 for IC Block Diagrams. (Page 53) (4/6) C1963 C1952 C1953 FB1427 C1403 C1413 R1458 JR1463 C1954 R1423 C1443 R1970 AF22 R1463 R1981 C1965 R1982 AF20 FB1418 DC CUT DIGITAL FILTER...
Page 56: Schematic Diagram - D-Amp Section (5/6)
STR-DA5000ES 6-37. SCHEMATIC DIAGRAM – D-AMP Section (5/6) – • See page 78 for IC Block Diagrams. (Page 54) (5/6) CN1851 D1524 FB1524 1SS367 R1514 C1851 IC1534 C1594 HIP2101IB 100V (Page 76) C1614 R1704 0.015 100k Q1724 2SA1163 PROTECT C064...
Page 57: Schematic Diagram - D-Amp Section (6/6)
STR-DA5000ES 6-38. SCHEMATIC DIAGRAM – D-AMP Section (6/6) – • See page 78 for IC Block Diagrams. (Page 56) (6/6) (CHASSIS) D1526 FB1526 1SS367 (CHASSIS) R1516 R1706 IC1536 C1596 100k HIP2101IB C1616 0.015 Q1726 2SA1163 R1656 R1716 PROTECT Q1656 SUP18N15-95...
Page 58: Printed Wiring Board - Pre-Out Board (Component Side) - (Us, Cnd Models)
STR-DA5000ES 6-39. PRINTED WIRING BOARD – PRE-OUT Board (Component Side) – (US, CND models) • :Uses unleaded solder. See page 29 for Circuit Boards Location. • Semiconductor Location Ref. No. Location IC2812 IC2813 PRE-OUT BOARD (COMPONENT SIDE) IC2862 IC2863 IC2912...
Page 59: Printed Wiring Board - Pre-Out Board (Conductor Side) - (Us, Cnd Models)
STR-DA5000ES 6-40. PRINTED WIRING BOARD – PRE-OUT Board (Conductor Side) – (US, CND models) • :Uses unleaded solder. See page 29 for Circuit Boards Location. • Semiconductor Location Ref. No. Location AUDIO BOARD AUDIO BOARD REG BOARD REG BOARD D2801...
Page 60: Schematic Diagram - Pre-Out Board - (Us, Cnd Models)
STR-DA5000ES 6-41. SCHEMATIC DIAGRAM – PRE-OUT Board – (US, CND models) • See page 78 for IC Block Diagrams. Q2800 DTA114TKA BUFFER R2903 R2853 R2803 R2953 Q2951 Q2901 Q2851 Q2801 (Page 33) 2SC2712-YG 2SC2712-YG 2SC2712-YG 2SC2712-YG R2952 R2902 R2852 R2802 4.7k...
Page 61: Schematic Diagram - Video Board (1/3)
STR-DA5000ES 6-42. SCHEMATIC DIAGRAM – VIDEO Board (1/3) – • • See page 38 for Waveforms. See page 78 for IC Block Diagrams. (1/3) C3724 IC3702 C3722 BA033T 100p X3703 +3.3V REGULATOR 500KHz C3719 IC3731 LA7213 C3725 SYNC DETECT C3726...
Page 62: Schematic Diagram - Video Board (2/3)
STR-DA5000ES 6-43. SCHEMATIC DIAGRAM – VIDEO Board (2/3) – • • See page 38 for Waveforms. See page 78 for IC Block Diagrams. (Page 46) CN3806 (2/3) C3201 IC3201 ADM3222 R2OUT T2IN R2IN RX232 C3202 T1IN T2OUT CN3801 TX232 IIC-DATA...
Page 63: Schematic Diagram - Video Board (3/3)
STR-DA5000ES 6-44. SCHEMATIC DIAGRAM – VIDEO Board (3/3) – • • See page 38 for Waveforms. See page 78 for IC Block Diagrams. (Page 61) (3/3) C3641 MODE R3649 C3455 C3456 R3451 L3601 22µH C3671 R3648 1.5k VIDEO AMP VIDEO AMP...
Page 64: Video Board (Component Side)
STR-DA5000ES 6-45. PRINTED WIRING BOARD – VIDEO Board (Component Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. VIDEO BOARD (COMPONENT SIDE) IC3721 R3731 IC3751 IC3812 IC3813 IC3811 IC3661 D3732 IC3701 C3751 IC3501 R3624 IC3741 (US, CND)
Page 65: Printed Wiring Board - Video Board (Conductor Side)
STR-DA5000ES 6-46. PRINTED WIRING BOARD – VIDEO Board (Conductor Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. RY3301 – 3306 (US, CND) DIGITAL BOARD S-VIDEO BOARD REG BOARD CIS BOARD DIGITAL BOARD CN2675 CNS741 CN907...
Page 66: Printed Wiring Board - S-Video Board
STR-DA5000ES 6-47. PRINTED WIRING BOARD – S-VIDEO Board – • See page 29 for Circuit Boards Location. :Uses unleaded solder. • Semiconductor Location Ref. No. Location S-VIDEO BOARD (COMPONENT SIDE) D741 S-VIDEO BOARD (CONDUCTOR SIDE) D742 IC701 IC702 R738 R737...
Page 67: Schematic Diagram - S-Video Board
STR-DA5000ES 6-48. SCHEMATIC DIAGRAM – S-VIDEO Board – • See page 78 for IC Block Diagrams. D741 1SS355TE R701 CNS741 C701 D742 1SS355TE MONITOR-C/OUT J701 R705 MONITOR-Y/OUT MONITOR R702 100k C702 S2 VIDEO R704 MONITOR-C/IN 1000 R741 6.3V MONITOR-Y/IN R703...
Page 68: Printed Wiring Board - Cis Board - (Us, Cnd Models)
STR-DA5000ES 6-49. PRINTED WIRING BOARD – CIS Board – (US, CND models) • See page 29 for Circuit Boards Location. :Uses unleaded solder. • Semiconductor Location Ref. No. Location D801 D802 CIS BOARD CIS BOARD (CONDUCTOR SIDE) (COMPONENT SIDE) D803...
Page 69: Schematic Diagram - Cis Board - (Us, Cnd Models)
STR-DA5000ES 6-50. SCHEMATIC DIAGRAM – CIS Board – (US, CND models) • See page 78 for IC Block Diagrams. J801 REMOTE CONTROL IR IN D802 RECEIVER(REAR) SID307BRTP19 IC801 REMOTE NJL63H400A J802 D801 R801 CONTROL 1SS355TE-17 IR OUT1 TRANSCEIVER REMOTE J803...
Page 70: Printed Wiring Board - Fl Board
STR-DA5000ES 6-51. PRINTED WIRING BOARD – FL Board – • :Uses unleaded solder. See page 29 for Circuit Boards Location. DIGITAL BOARD CN2007 (Page 49) FL BOARD R1001 FL1001 CN1001 C1002 C1003 IC1001 R1007 JW1080 R1010 R1011 JW1079 R1006 R1009...
Page 71: Schematic Diagram - Fl Board
STR-DA5000ES 6-52. SCHEMATIC DIAGRAM – FL Board – MENU1 ENC-MENU1 MENU2 ENC-MENU2 MAIN1 ENC-PAGE1 MAIN2 ENC-PAGE2 ENC-C1 ENC-+/-1 ENC-C2 ENC-+/-2 TRE1 TRE 1 TRE2 TRE 2 BASS1 BASS 1 CN1001 BASS2 BASS 2 HP.-SW A/D1 VOL 2 R1013 A/D2 VOL 1...
Page 72: Printed Wiring Boards - Panel Section
STR-DA5000ES 6-53. PRINTED WIRING BOARDS – PANEL Section – • :Uses unleaded solder. See page 29 for Circuit Boards Location. POWER SW BOARD LED BOARD S1013 – 1018 FL BOARD (Page 70) CN1003 KEY BOARD PHONES D1201 – 1022 CN1018...
Page 73: Schematic Diagram - Panel Section
STR-DA5000ES 6-54. SCHEMATIC DIAGRAM – PANEL Section – CN1018 A/D 1 DGND S1013 FUNC 2 DGND FUNC 1 R1056 R1057 R1058 (Page 71) (Page 71) 2.2k 2.2k CN1005 CN1023 R1055 4.7k S1015 S1016 S1017 S1018 MUSIC MOVIE A.F.D S1014 INPUT...
Page 74: Printed Wiring Board - Reg Section (Component Side)
STR-DA5000ES 6-55. PRINTED WIRING BOARD – REG Section (Component Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. REG BOARD (COMPONENT SIDE) C906 JW901 R907 (US, CND) IC940 R935 R936 R930 Q914 R939 R937 R938 D902...
Page 75: Printed Wiring Boards - Reg Section (Conductor Side)
STR-DA5000ES 6-56. PRINTED WIRING BOARDS – REG Section (Conductor Side) – • :Uses unleaded solder. See page 29 for Circuit Boards Location. D-AMP BOARD (Page 51) CN1701 (Page 51) D-AMP BOARD CN1702, 1703 (Page 51) D-AMP BOARD D-AMP BOARD (Page 51)
Page 76: Schematic Diagram - Reg Section (1/2)
STR-DA5000ES 6-57. SCHEMATIC DIAGRAM – REG Section (1/2) – (Page 69) (Page 33) (Page 52) (US,CND) (Page 62) (Page 47) CN906 CN907 CN908 CN909 (1/2) (Page 52) CN903 V-9V VGND C907 470 16V (US, CND) 1000 16V (EXCEPT US, CND)
Page 77: Schematic Diagram - Reg Section (2/2)
STR-DA5000ES 6-58. SCHEMATIC DIAGRAM – REG Section (2/2) – • See page 78 for IC Block Diagrams. (Page 55) (FOR ADJUSTMENT) CN919 CN911 (2/2) CN912 A+5V C929 100 16V A-10V AUGND BUFFER A+10V (Page 33) C951 R1027 2.2k R984 R1021...
Page 78 STR-DA5000ES • IC Block Diagrams – AUDIO Board – IC326, 341 TC9274N-016 IC401, 501 TC9274N-015 IC601 TC9273N-013 10BIT 10BIT LATCH LATCH CIRCUIT CIRCUIT (L-CH) (R-CH) 18BIT 18BIT 18BIT 18BIT LATCH LATCH LATCH LATCH CIRCUIT CIRCUIT CIRCUIT CIRCUIT (L-CH) (R-CH) (L-CH)
Page 79 STR-DA5000ES – DIGITAL Board – IC2005 TC74HC151AF (EL) IC2007 TC7WH08FU (TE12R) IC2010 PCM1802DBR SINGLE-END/ 5TH ORDER MODE1 VINL 1 DIFFERENTIAL DELTA-SIGMA MODE0 CONVERTER MODULATOR FMT1 VINR 2 x16 1/64 FMT0 (x1/128) SERIAL INTERFACE DECIMATION VREF1 3 SCKI REFERENCE FILTER &...
Page 80 STR-DA5000ES IC2012–2015 DSD1800DBR VREFL VREFR VREF L VREF R AGNDL AGNDR VCOML VCOMR VINL+ VINR+ DELTA-SIGMA DELTA-SIGMA VINL– VINR– MODULATOR (L) MODULATOR (R) DGND AGND SERIAL OUTPUT INTERFACE SCKI DSDR CONTROL DSDL IC2121 LC89056W-E IC2123, 2207 TC7WH157FU (TE12R) 11 7...
Page 81 STR-DA5000ES IC2008, 2461, 2462 TC74HC595AF (EL) – D-AMP Board – IC1400 TC74AC125FT (EL) 14 VCC 1 OE 4 OE SHIFT REGISTER 2 OE LATCH 3 OE PARALLEL DATA OUTPUT IC1401–1404 CXD9730Q XFSIIN 64 XFSIIN OUTR2+ VDDR2+ CLOCK CLOCK GENERATOR GENERATOR VDDR2–...
Page 82 STR-DA5000ES IC1531–1537, 1541–1547 HIP2101IBZT IC1841 M62342FP VDD 1 8BIT SUPERIOR 8BIT DRIVE SEGMENT LATCH R-2R 10BIT SHIFT REGISTER HB 2 8BIT SUPERIOR 8BIT CHANNEL SEGMENT LATCH DRIVE HO 3 DECODER R-2R CONTROL HS 4 IC1950 CXD9776AQ 28 27 PBBCK PBWCK...
Page 83 STR-DA5000ES IC2862 CXD9725M TRIM VOLUME TRIM VOLUME 24 VDD 0-+24dB/ 0-+24dB/ 1dB STEP 1dB STEP TRIM 23 TRIM 5 to 25 DECODER 5 to 25 DECODER & & LATCH CIRCUIT LATCH CIRCUIT TRIM 22 TRIM TRIM 21 TRIM 20 OUT...
Page 84 STR-DA5000ES IC3321 LA7106M-TLM IC3421, 3431 NJM-2296M-TE2 V1OUT V1IN V2OUT V2IN VIN1+ 75Ω 16 +VCC DRIVER NFB1 15 VOUT1 MUTE1 14 GND VIN2+ 75Ω 13 VOUT2 DRIVER NFB2 12 DR CTL –VCC1 11 VOUT3 75Ω DRIVER VIN3+ 10 MUTE2 NFB3 9 –VCC2 M.OUT...
Page 85 STR-DA5000ES IC3601 CXD2064Q 4fsc 24 DTR CKSL 23 PNR PLSL PHASE MCKO COMPARATOR 22 VEH1 ADCK 21 VEH2 20 VEH3 PLVS 19 MOD1 PLVD 18 DVSS VERTICAL CONTOUR ACCENTUATION CIRCUIT CLVD 17 MOD2 NTSC: 1H NTSC: 1H CLPEN PAL : 2H...
Page 86 STR-DA5000ES IC3701 CXA2199Q 22 21 X' TAL PIN CLAMP 4.43/3.58 SECAM S GND DET SW CHROMA CHROMA PHASE COLOR EXT COLOR SHIFT KILLER NT/PAL COLOR COLOR PHASE V PED AXIS KILLER ID AXIS DELAY PAL ID BST AMP V PED...
Page 87 STR-DA5000ES IC3721 TDA4662T-V3 PRE-AMPLIFIERS SAMPLE LINE MEMORY HOLD SIGNAL VI (R-Y) CLAMPING N. C. N. C. SAMPLE LINE GND2 MEMORY HOLD SIGNAL VI (B-Y) CLAMPING I. C. N. C. FREQUENCY SANDCASTLE DIVIDER SAND PHASE VO (B-Y) DETECTOR BY 192 DETECTOR N.
Page 88 STR-DA5000ES IC702 NJM2596M (TE2) 75Ω 75Ω 75Ω DRIVER DRIVER DRIVER COMP – CIS Board – – FL Board – IC861 NJM2145M-TE2 IC1004 NJU3716M-T2 OUT1 INH1 18 17 16 15 14 13 INH2 INPUT CIRCUIT CONTROL CIRCUIT OUT2-1 OUTPUT CIRCUIT SHIFT REGISTER...
Page 89 STR-DA5000ES – REG Board – IC931 DSD1751DBQR DSDL DBCK DSDR DSCK FILTER PSCK PBCK MODE PDATA FILTER CONTROL MULTI-LEVEL (X8 DF) DELTA-SIGMA PLRCK MODULATOR DGND ZEROR/ZEROA ZEROL/NA MULTI-LEVEL VOUTL ANALOG VOUTR VCOM AGND IC940, 941 TC74VHC541FT (EL) 20 19 IC2801 DSD1608PAHR...
Page 90: Ic Pin Function Description
STR-DA5000ES 6-59. IC PIN FUNCTION DESCRIPTION • DIGITAL BOARD IC2121 LC89056W-E (DIGITAL AUDIO INTERFACE RECEIVER) Pin No. Pin Name Description DISEL Selection signal input terminal of data input terminal Fixed at “L” in this set DOUT Digital data output to the external output terminal Not used...
Page 91 STR-DA5000ES Pin No. Pin Name Description Relay drive signal output terminal SHIFT Serial data transfer clock signal output to the PCM/PWM processor /SO1 SCDT Serial data output to the PCM/PWM processor /SI1 SR-B Relay drive signal output terminal Not used...
Page 92 STR-DA5000ES • DIGITAL BOARD IC2201 CXD9718Q (DIGITAL SIGNAL PROCESSOR) Pin No. Pin Name Description — Ground terminal XRST System reset signal input from the main system controller “L”: reset EXTIN Master clock signal input terminal Not used Sampling frequency selection signal input terminal Not used —...
Page 93 STR-DA5000ES Pin No. Pin Name Description — VDDE Power supply terminal (+3.3V) WMD1 External memory wait mode setting terminal Fixed at “H” in this set — Ground terminal WMD0 External memory wait mode setting terminal Fixed at “H” in this set...
Page 94 STR-DA5000ES Pin No. Pin Name Description 114, 115 SDI3, SDI4 Audio serial data input terminal Not used SYNC Sync/non-sync setting terminal “L”: sync, “H”: non-sync Fixed at “H” in this set 117 to 119 — Ground terminal — VDDI Power supply terminal (+2.5V)
Page 95 STR-DA5000ES • DIGITAL BOARD IC2251 CXD9616BR (DIGITAL SIGNAL PROCESSOR) Pin No. Pin Name Description VDDI — Power supply terminal (+2.5V) EXTIN Master clock signal input terminal Not used WMD1, WMD0 3, 4 External memory wait mode setting terminal Fixed at “H” in this set Operation mode setting terminal “L”: enhanced mode, “H”: normal mode...
Page 96 STR-DA5000ES Pin No. Pin Name Description — Ground terminal D21 to D19 56 to 58 Two-way data bus with the S-RAM Address signal output to the S-RAM 60, 61 SDO1, SDO2 Audio serial data output to the lip sync adjust...
Page 97 STR-DA5000ES Pin No. Pin Name Description — Ground terminal GP5, GP4 — 118, 119 Not used Error signal output to the main system controller — Not used Address signal output to the S-RAM D4 to D2 123 to 125 Two-way data bus with the S-RAM VDDE —...
Page 98 STR-DA5000ES • DIGITAL BOARD IC2401, IC2426 ISPLSI2032VE-110LTN44-MOD (GPR) Pin No. Pin Name Description EDGE Clock signal input terminal BCKIN Bit clock signal input terminal BCK2IN Not used (open) Not used (open) Serial data transfer clock signal input terminal — Power supply terminal (+3.3V) BSCAM —...
Page 99 STR-DA5000ES • DIGITAL BOARD IC2301 CXD9722TQ (LIP SYNC ADJUST) Pin No. Pin Name Description 1 to 5 D1 to D5 Serial data input/output terminal with the DRAM — Power supply terminal (+3.3V) 7, 8 D6, D7 Serial data input/output terminal with the DRAM —...
Page 100 STR-DA5000ES Pin No. Pin Name Description BCKI Bit clock signal (2.8224 MHz) input from the digital signal processor — Power supply terminal (+3.3V) — Ground terminal DLDRI Audio serial data input from the digital signal processor CSWI Audio serial data input from the digital signal processor...
Page 101 STR-DA5000ES • DIGITAL BOARD IC2601 MB91F155-3ES-X100 (MAIN SYSTEM CONTROLLER) Pin No. Pin Name Description DSP CLK Serial data transfer clock signal output to the digital signal processor DSP HDIN Serial data output to the digital signal processor 1BST SEL Boot strap signal output to the clock select 1XRST System reset signal output to the digital signal processor “L”: reset...
Page 102 STR-DA5000ES Pin No. Pin Name Description FUNCLAT Serial data latch pulse output to the TC74HCT7007AF D.MIXLAT Serial data latch pulse output to the TC74HCT7007AF VDLLAT Serial data latch pulse output to the TC74HCT7007AF UPCONLAT Serial data latch pulse output terminal Not used...
Page 103 STR-DA5000ES Pin No. Pin Name Description VOLJOG2 Jog dial pulse input from the rotary encoder (for MASTER VOLUME) BASSJOG1 Jog dial pulse input from the rotary encoder (for BASS) BASSJOG2 Jog dial pulse input from the rotary encoder (for BASS)
Page 104 STR-DA5000ES Pin No. Pin Name Description RDSSIGNAL RDS signal input from the tuner unit HP-SW Headphone detection signal input terminal “H”: headphone is connected +/-JOG1 Jog dial pulse input from the rotary encoder (for -/+) +/-JOG2 Jog dial pulse input from the rotary encoder (for -/+) VCC2 —...
Page 105 STR-DA5000ES • DIGITAL BOARD IC2701 TMP87C447U-1F23 (SUB SYSTEM CONTROLLER) Pin No. Pin Name Description STAT0 M-BUS status output to the main system controller CARRIER-OUT SIRCS signal on/off signal output terminal FLASH — Not used (Connected to VDD) MBUS — Not used (Connected to VDD)
Page 106 STR-DA5000ES • D-AMP BOARD IC1800 B89F538L (SUB SYSTEM CONTROLLER) Pin No. Pin Name Description I LIMIT Current detection MOD2 Not used (connected to ground) TEMP Thermistor connection terminal for temperature detection (A/D input) 4 to 10 — — Not used (open) AVCC —...
Page 107 STR-DA5000ES Pin No. Pin Name Description /SI1 SR-B Relay drive signal output terminal Not used C RY Not used (open) SB RY Not used (open) — Power supply terminal (+3.3V) SP RY Relay drive signal output terminal Not used (open)
Page 108 STR-DA5000ES • VIDEO BOARD IC3501 MB90089F-G-238-BND (OSD DRIVER) Pin No. Pin Name Description Y (luminance) signal input Not used C (color) signal input Not used Composite video signal input Not used AVCC — Power supply terminal (+5V) (for analog) FSCO...
Page 109: Exploded Views
STR-DA5000ES SECTION 7 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they • Items marked “*” are not stocked since they The components identified by mark 0 or dotted line with mark may have some difference from the original are seldom required for routine service.
Page 110: Front Panel Section-1
4-246-103-22 KNOB (SPEAKER) (BLACK) A-4733-990-A FL BOARD, COMPLETE (EXCEPT AEP: BLACK) 3-354-981-01 SPRING (SUS), RING A-4734-079-A FL BOARD, COMPLETE (AEP: BLACK) 4-942-568-41 EMBLEM (NO.5), SONY (for BLACK) 1-827-364-11 WIRE (FLAT TYPE) (23 CORE) A-4733-995-A POWER SW BOARD, COMPLETE 1-688-724-11 JOG BOARD 4-951-620-01 SCREW (2.6X8), +BVTP...
Page 111: Front Panel Section-2
STR-DA5000ES 7-3. FRONT PANEL SECTION-2 not supplied not supplied not supplied not supplied supplied supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-246-526-02 LID (SILVER) 4-246-509-21 PANEL, FRONT (BLACK) 4-246-526-11 LID (GOLD) 4-246-509-81 PANEL, FRONT (GOLD: TW, CH)
Page 112: Chassis Section-1
STR-DA5000ES 7-4. CHASSIS SECTION-1 TU2051 (US, CND) (US, CND) not supplied (US, CND) not supplied not supplied (US, CND) supplied chassis section-2 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-655-653-11 BAND (TAITON), BINDING 1-773-007-11 WIRE (FLAT TYPE) (15 CORE) (AEP)
Page 113: Chassis Section-2
STR-DA5000ES 7-5. CHASSIS SECTION-2 not supplied (Refer to page 110) (Refer to page 110) not supplied not supplied supplied (EXCEPT US, CND) not supplied chassis section-3 The components identified by Les composants identifiés par une mark 0 or dotted line with marque 0 sont critiques pour la mark 0 are critical for safety.
Page 114: Chassis Section-3
STR-DA5000ES 7-6. CHASSIS SECTION-3 not supplied not supplied not supplied REG board section not supplied not supplied chassis section-4 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4733-994-A VIDEO3 BOARD, COMPLETE 1-688-732-11 THERMISTOR BOARD 1-469-854-11 CORE, FERRITE...
Page 115: Chassis Section-4
STR-DA5000ES 7-7. CHASSIS SECTION-4 (US, CND) not supplied (EXCEPT US, CND) not supplied (US, CND) (US, CND) not supplied supplied with J3201 not supplied chassis section-5 not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No.
Page 116: Chassis Section-5
STR-DA5000ES 7-8. CHASSIS SECTION-5 (US, CND) (EXCEPT US, CND) not supplied (US, CND) not supplied not supplied not supplied not supplied not supplied D-AMP board section not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No.
Page 117: Reg Board Section
STR-DA5000ES 7-9. REG BOARD SECTION Q909 IC904 not supplied supplied with Q909 Q904 IC905 IC906 IC909 IC910 not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4734-008-A REG BOARD, COMPLETE (US, CND) IC906...
Page 118: D-Amp Board Section
STR-DA5000ES 7-10. D-AMP BOARD SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4734-017-A D-AMP BOARD, COMPLETE (US, CND) 1-860-494-11 SP TM (E) BOARD A-4734-075-A D-AMP BOARD, COMPLETE (TW, CH) 1-860-495-11 SP TM (F) BOARD 1-860-496-11 SP TM (G) BOARD...
Page 119: Electrical Parts List
STR-DA5000ES SECTION 8 ELECTRICAL PARTS LIST ANALOG SUB NOTE: The components identified by • Due to standardization, replacements in the • Items marked “*” are not stocked since they mark 0 or dotted line with mark 0 are critical for safety.
Page 120 STR-DA5000ES ANALOG SUB AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R120 1-216-675-11 METAL CHIP 0.5% 1/10W R141 1-216-619-11 METAL CHIP 0.5% 1/10W R262 1-216-675-11 METAL CHIP 0.5% 1/10W R142 1-216-675-11 METAL CHIP 0.5% 1/10W...
Page 121 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C162 1-119-825-41 ELECT 22uF C406 1-163-251-11 CERAMIC CHIP 100PF (EXCEPT US, CND) (EXCEPT US, CND) C162 1-128-858-11 ELECT 22uF C407 1-163-251-11 CERAMIC CHIP 100PF (US, CND)
Page 122 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C445 1-137-505-11 MYLAR 220PF 100V C517 1-163-251-11 CERAMIC CHIP 100PF (US, CND) (EXCEPT US, CND) C446 1-128-858-11 ELECT 22uF C518 1-163-251-11 CERAMIC CHIP 100PF (US, CND)
Page 123 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C586 1-164-161-11 CERAMIC CHIP 0.0022uF 10% C694 1-136-169-00 MYLAR 0.22uF C587 1-163-038-00 CERAMIC CHIP 0.1uF C588 1-163-251-11 CERAMIC CHIP 100PF C695 1-136-169-00 MYLAR 0.22uF C591 1-163-251-11 CERAMIC CHIP...
Page 124 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC620 8-759-832-29 IC NJM4580M-(TE2) R125 1-216-238-00 RES-CHIP 1/8W IC621 8-759-832-29 IC NJM4580M-(TE2) (US, CND) R125 1-260-016-11 CARBON MELF 1/8W IC641 8-759-832-29 IC NJM4580M-(TE2) (US, CND) (EXCEPT US, CND)
Page 125 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R168 1-260-016-11 CARBON MELF 1/8W R233 1-208-810-11 METAL CHIP 0.5% 1/10W (EXCEPT US, CND) (US, CND) R187 1-216-238-00 RES-CHIP 1/8W R233 1-260-010-11 CARBON MELF 1/8W (US, CND)
Page 126 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R404 1-208-782-11 METAL CHIP 0.5% 1/10W R422 1-260-016-11 CARBON MELF 1/8W (US, CND) (EXCEPT US, CND) R404 1-259-995-11 CARBON MELF 1/8W (EXCEPT US, CND) R423 1-216-238-00 RES-CHIP...
Page 127 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R456 1-208-453-41 RES-CHIP 4.7K 1/10W R506 1-208-782-11 METAL CHIP 0.5% 1/10W (US, CND) (US, CND) R506 1-259-995-11 CARBON MELF 1/8W R457 1-208-437-41 RES-CHIP 1/10W (EXCEPT US, CND)
Page 128 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R524 1-260-016-11 CARBON MELF 1/8W R562 1-216-222-00 RES-CHIP 1/8W (EXCEPT US, CND) (US, CND) R525 1-216-238-00 RES-CHIP 1/8W R562 1-260-008-11 CARBON MELF 1/8W (US, CND) (EXCEPT US, CND)
Page 129 STR-DA5000ES AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 0 R656 1-249-393-11 CARBON 1/4W F < IC > (US, CND) R657 1-216-295-00 SHORT CHIP 0 (US, CND) IC801 8-759-827-69 IC NJL63H400A-1 IC802 8-759-564-49 IC TC7W53FU (TE12R)
Page 130 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4734-017-A D-AMP BOARD, COMPLETE (US, CND) C1361 1-100-156-91 CERAMIC CHIP 680PF 100V A-4734-075-A D-AMP BOARD, COMPLETE (TW, CH) C1362 1-100-156-91 CERAMIC CHIP 680PF 100V A-4734-093-A D-AMP BOARD, COMPLETE (AEP)
Page 131 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1427 1-162-962-11 CERAMIC CHIP 470PF C1495 1-162-927-11 CERAMIC CHIP 100PF C1428 1-162-962-11 CERAMIC CHIP 470PF C1496 1-162-927-11 CERAMIC CHIP 100PF C1429 1-162-962-11 CERAMIC CHIP 470PF C1497...
Page 132 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1574 1-100-621-11 ELECT 470uF C1667 1-100-623-91 CERAMIC CHIP 0.1uF 100V C1575 1-100-621-11 ELECT 470uF C1671 1-100-623-91 CERAMIC CHIP 0.1uF 100V C1576 1-100-621-11 ELECT 470uF C1577 1-100-621-11 ELECT...
Page 133 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1705 1-130-777-00 MYLAR 0.1uF 100V C1723 1-130-777-00 MYLAR 0.1uF 100V (EXCEPT AEP) (EXCEPT AEP) C1706 1-100-622-21 MYLAR 0.1uF 100V C1724 1-100-622-21 MYLAR 0.1uF 100V (AEP) (AEP)
Page 134 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1785 1-117-720-11 CERAMIC CHIP 4.7uF C1891 1-164-156-11 CERAMIC CHIP 0.1uF C1786 1-117-720-11 CERAMIC CHIP 4.7uF C1892 1-119-799-11 ELECT 47uF C1787 1-117-720-11 CERAMIC CHIP 4.7uF (EXCEPT AEP)
Page 135 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2872 1-163-021-11 CERAMIC CHIP 0.01uF D1891 8-719-820-05 DIODE 1SS181 (EXCEPT US, CND) C2873 1-162-966-11 CERAMIC CHIP 0.0022uF 10% D2851 8-719-016-74 DIODE 1SS352 (EXCEPT US, CND) (EXCEPT US, CND) <...
Page 136 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC1481 8-759-832-29 IC NJM4580M-(TE2) L1305 1-456-412-11 COIL, CHOKE 10uH IC1482 8-759-832-29 IC NJM4580M-(TE2) IC1511 8-759-523-08 IC TC74AC08FT (EL) L1306 1-456-412-11 COIL, CHOKE 10uH IC1512 8-759-523-08 IC TC74AC08FT (EL)
Page 137 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q1686 6-550-622-01 FET SUP18N15-95 R1306 1-216-797-11 METAL CHIP 1/10W Q1687 6-550-622-01 FET SUP18N15-95 R1307 1-216-797-11 METAL CHIP 1/10W R1311 1-216-797-11 METAL CHIP 1/10W Q1690 8-729-230-49 TRANSISTOR...
Page 138 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1525 1-216-815-11 METAL CHIP 1/10W R1443 1-216-809-11 METAL CHIP 1/10W R1444 1-216-809-11 METAL CHIP 1/10W R1526 1-216-815-11 METAL CHIP 1/10W R1451 1-216-809-11 METAL CHIP 1/10W R1527...
Page 139 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1642 1-219-796-11 RES-CHIP 0.025 R1731 1-216-849-11 METAL CHIP 220K 1/10W R1732 1-216-849-11 METAL CHIP 220K 1/10W R1643 1-219-796-11 RES-CHIP 0.025 R1733 1-216-849-11 METAL CHIP 220K 1/10W...
Page 140 STR-DA5000ES D-AMP Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1813 1-216-809-11 METAL CHIP 1/10W R1927 1-216-833-11 METAL CHIP 1/10W R1928 1-216-833-11 METAL CHIP 1/10W R1814 1-216-809-11 METAL CHIP 1/10W R1815 1-216-833-11 METAL CHIP 1/10W R1931...
Page 141 STR-DA5000ES D-AMP DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2889 1-260-020-11 CARBON MELF 100K 1/8W TM1760 1-780-025-21 TERMINAL BOARD (SP) (2P) (AEP) (SURROUND BACK SPEAKERS IMPEDANCE USE 4-16O) (EXCEPT US, CND) R2890 1-216-246-00 RES-CHIP...
Page 142 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2026 1-119-824-11 ELECT 10uF C2045 1-135-743-11 ELECT 10uF (US, CND) (TW, CH) C2026 1-135-743-11 ELECT 10uF C2046 1-165-319-11 CERAMIC CHIP 0.1uF (TW, CH) C2027 1-165-319-11 CERAMIC CHIP 0.1uF...
Page 143 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2067 1-119-824-11 ELECT 10uF C2123 1-163-251-11 CERAMIC CHIP 100PF (US, CND) C2124 1-119-779-11 ELECT 220uF C2067 1-135-743-11 ELECT 10uF (AEP) (TW, CH) C2124 1-128-832-11 ELECT 220uF...
Page 144 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2216 1-165-319-11 CERAMIC CHIP 0.1uF C2307 1-119-800-11 ELECT 100uF C2219 1-165-319-11 CERAMIC CHIP 0.1uF (AEP) C2220 1-165-319-11 CERAMIC CHIP 0.1uF C2307 1-127-718-91 ELECT 100uF C2221 1-119-780-11 ELECT...
Page 145 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2506 1-163-021-11 CERAMIC CHIP 0.01uF C2710 1-119-800-11 ELECT 100uF C2507 1-125-838-11 CERAMIC CHIP 2.2uF 6.3V (AEP) C2710 1-127-718-91 ELECT 100uF C2508 1-125-838-11 CERAMIC CHIP 2.2uF 6.3V...
Page 146 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D2000 8-719-073-35 DIODE RB551V-30TE-17 IC2002 6-600-014-01 IC TORX141L D2010 8-719-988-61 DIODE 1SS355TE-17 (DIGITAL, MD/DAT OPTICAL IN) D2122 8-719-988-61 DIODE 1SS355TE-17 IC2003 6-600-014-01 IC TORX141L (DIGITAL, TV/SAT OPTICAL IN)
Page 147 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC2703 8-759-008-37 IC MC74HC4050F R2014 1-216-238-00 RES-CHIP 1/8W (EXCEPT AEP) IC2704 8-759-238-47 IC TC74HCT7007AF (EL) R2014 1-260-016-11 CARBON MELF 1/8W IC2705 8-759-058-62 IC TC7S08FU (TE85R) (AEP)
Page 148 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2255 1-216-627-11 METAL CHIP 0.5% 1/10W R2143 1-216-635-11 METAL CHIP 0.5% 1/10W R2256 1-216-627-11 METAL CHIP 0.5% 1/10W R2144 1-216-699-11 METAL CHIP 100K 0.5% 1/10W R2257 1-216-627-11 METAL CHIP 0.5%...
Page 149 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2435 1-216-627-11 METAL CHIP 0.5% 1/10W R2316 1-216-627-11 METAL CHIP 0.5% 1/10W R2436 1-216-627-11 METAL CHIP 0.5% 1/10W R2317 1-216-627-11 METAL CHIP 0.5% 1/10W R2437 1-216-627-11 METAL CHIP 0.5%...
Page 150 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2614 1-208-437-41 RES-CHIP 1/10W (TW, CH) R2674 1-216-627-11 METAL CHIP 0.5% 1/10W R2614 1-216-295-00 SHORT CHIP 0 (US, CND, AEP) R2675 1-216-627-11 METAL CHIP 0.5% 1/10W...
Page 151 STR-DA5000ES DIGITAL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2803 1-216-627-11 METAL CHIP 0.5% 1/10W D1006 8-719-313-50 LED SEL6810A-TH12 (CD/SACD) R2804 1-216-627-11 METAL CHIP 0.5% 1/10W R2805 1-216-627-11 METAL CHIP 0.5% 1/10W D1007 8-719-313-50 LED SEL6810A-TH12 (MD/DAT)
Page 152 STR-DA5000ES FUNCTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1026 1-164-161-11 CERAMIC CHIP 0.0022uF 10% R1028 1-216-057-00 RES-CHIP 2.2K 1/10W C1027 1-164-161-11 CERAMIC CHIP 0.0022uF 10% R1029 1-216-057-00 RES-CHIP 2.2K 1/10W C1041 1-165-319-11 CERAMIC CHIP 0.1uF...
Page 153 STR-DA5000ES POWER SW POWER SW SUB PRE-OUT Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-688-731-11 LED BOARD C2815 1-128-858-11 ELECT 22uF ********** C2816 1-128-832-11 ELECT 220uF < CONNECTOR > C2817 1-137-505-11 MYLAR 220PF 100V C2818...
Page 154 STR-DA5000ES PRE-OUT Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C2988 1-128-858-11 ELECT 22uF R2839 1-216-699-11 METAL CHIP 100K 0.5% 1/10W C2989 1-163-251-11 CERAMIC CHIP 100PF R2840 1-208-826-11 METAL CHIP 0.5% 1/10W R2842 1-216-627-11 METAL CHIP 0.5%...
Page 155 STR-DA5000ES PRE-OUT Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R2992 1-216-627-11 METAL CHIP 0.5% 1/10W C931 1-165-319-11 CERAMIC CHIP 0.1uF (US, CND) R2993 1-208-437-41 RES-CHIP 1/10W C933 1-128-832-11 ELECT 220uF (US, CND) < RELAY >...
Page 156 STR-DA5000ES Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C972 1-137-365-11 MYLAR 0.0015uF 5% C4007 1-165-319-11 CERAMIC CHIP 0.1uF (US, CND) C4008 1-165-319-11 CERAMIC CHIP 0.1uF C973 1-137-365-11 MYLAR 0.0015uF 5% (US, CND) C4009 1-119-825-11 ELECT...
Page 157 STR-DA5000ES Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC934 8-759-832-29 IC NJM4580M-(TE2) R935 1-216-025-11 RES-CHIP 1/10W IC935 8-759-832-29 IC NJM4580M-(TE2) (US, CND) (US, CND) IC936 8-759-832-29 IC NJM4580M-(TE2) (US, CND) R936 1-216-025-11 RES-CHIP 1/10W IC937...
Page 158 STR-DA5000ES S-VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R973 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10W R1001 1-216-025-11 RES-CHIP 1/10W (US, CND) (US, CND) R974 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10W (US, CND) R1002 1-216-025-11 RES-CHIP...
Page 159 STR-DA5000ES S-VIDEO SP TM (A) SP TM (B) SP TM (C) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C723 1-163-243-11 CERAMIC CHIP 47PF R713 1-216-022-00 RES-CHIP 1/10W C724 1-165-319-11 CERAMIC CHIP 0.1uF R714 1-216-022-00 RES-CHIP...
Page 160 STR-DA5000ES SP TM (D) SP TM (E) SP TM (F) SP TM (G) SP TM (H) SP TM (I) THERMISTOR VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-860-493-11 SP TM (D) BOARD CC088 1-100-156-91 CERAMIC CHIP...
Page 161 STR-DA5000ES VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3426 1-163-243-11 CERAMIC CHIP 47PF C3604 1-163-037-11 CERAMIC CHIP 0.022uF (US, CND) C3605 1-165-319-11 CERAMIC CHIP 0.1uF C3427 1-163-243-11 CERAMIC CHIP 47PF (US, CND) C3606 1-119-824-11 ELECT...
Page 162 STR-DA5000ES VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C3719 1-119-820-11 ELECT C3720 1-163-251-11 CERAMIC CHIP 100PF FB3603 1-469-152-11 FERRITE, EMI (SMD) (2012) C3721 1-165-319-11 CERAMIC CHIP 0.1uF FB3661 1-469-152-11 FERRITE, EMI (SMD) (2012) C3722...
Page 163 STR-DA5000ES VIDEO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark L3431 1-410-482-31 MICRO INDUCTOR 100uH R3421 1-216-022-00 RES-CHIP 1/10W L3432 1-410-482-31 MICRO INDUCTOR 100uH (US, CND) L3501 1-408-781-00 CHIP INDUCTOR 22uH R3422 1-216-022-00 RES-CHIP 1/10W (US, CND)
Page 164 STR-DA5000ES VIDEO VIDEO3 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R3645 1-216-033-00 RES-CHIP 1/10W C1029 1-163-009-11 CERAMIC CHIP 0.001uF C1030 1-163-009-11 CERAMIC CHIP 0.001uF R3646 1-216-085-00 RES-CHIP 1/10W C1032 1-163-009-11 CERAMIC CHIP 0.001uF R3647 1-216-081-00 RES-CHIP...
Page 165 STR-DA5000ES Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-400-583-11 CORE, FERRITE 4-247-233-31 MANUAL, INSTRUCTION, INSTALL 1-469-969-11 CLAMP, FERRITE (AEP, TW, KR) (GERMAN, DUTCH, ITALIAN) (AEP) 1-500-037-11 CORE, FERRITE (WITH CASE) 4-247-233-41 MANUAL, INSTRUCTION, INSTALL (SWEDISH, POLISH) (AEP)
Page 166 STR-DA5000ES MEMO...
Page 167 STR-DA5000ES US Model Canadian Model SERVICE MANUAL AEP Model E Model Chinese Model Ver 1.1 2004.09 SUPPLEMENT-1 Subject: Addition of “SPECIAL MENU MODE” 9-961-110-81...
Page 168 STR-DA5000ES SPECIAL MENU MODE Procedure: [MEMORY/ENTER] [MOVIE] 1. Press the button to turn on the main power, then while pressing the button, press the button in order. 2. The message “MENU EXPANDED !” appears. [MENU] 3. Each time the dial is turned clockwise, the item is switched in order as follows.
Page 169 STR-DA5000ES Items Display Remark DSP 2 ARAM DSP 2 ARAM The umbers which can be changed will blinks [TUNING +] [TUNING --] ] = XXXXXXXX ***** To select the digit: Press the button To select the number when the umbers (...
Page 170 STR-DA5000ES REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2003.08...

Sony STR-DA5000ES Service Manual

1 Servicing Notes

2 General

3 Disassembly

4 Test Mode

5 Electrical Adjustments

6 Diagrams

7 Exploded Views

8 Electrical Parts List

Quick Links

Related Manuals for Sony STR-DA5000ES

Summary of Contents for Sony STR-DA5000ES

Table of Contents